Polaris atv transmission oil substitute

rockman. 205 posts · Joined 2016. #16 · Mar 18, 2023. For your Sportsman 850 rear differential unit Polaris specifies GL5 80-90 as an alternative. Like JSMetalcraft says above "A JD20c hydraulic oil can be used in the front Hilliard unit". But I personally would use Demand Drive fluid when you can get it.

Polaris atv transmission oil substitute. I'd appreciate some assistance identifying a good reasonably priced alternative to Polaris AGL Gearcase Lubricant and Transmission Fluid for the main gearcase (combined diff/trans). I've seen references to the following, among others: Amsoil Synthetic Chaincase and Gear Oil. Pennzoil Synchromesh Manual Transmission Fluid. 5w20 Synthetic Motor Oil.

841 posts · Joined 2012. #15 · May 10, 2015. It doesnt need to state it but most all are but u definitely dont want one that says 2 stroke. Full synthetic in the right range is most important. 2015 Sportsman 1000 XP. 02 Sp700/'10 850 XP EPS sold. 2014 RZR 900 XP. 2000 Scrambler 400 2x4. -Trail Mod -RcR Ported.

Updated: The correct oil to use in a Polaris transmission is 10W-40 synthetic motor oil. If you’re wondering what kind of oil to use in your Polaris transmission, the answer is simple – any good quality automotive transmission fluid will work fine. Just make sure to check your owner’s manual for the specific type and amount of oil ...Oct 26, 2018 · Amsoil offers an alternative for oils. I use Schaeffer Supreme 9000 5w-50 for engine and their hydraulic oil for front and rear gearcase. I use full synthetic Amsoil for engine, trans, front drive and diff, cost is less than Polaris fluids and I believe they are far superior. AGL Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall the transmission fill plug. Torque to 14 ft-lbs (19 Nm). 12. Clean any residual fluid off the vehicle, and inspect for leaks. 13. Finally, dispose of the used fluid properly at your local ...When it comes to purchasing a Polaris ATV, finding the right dealer is crucial. Not only do you want a dealer that offers a wide selection of models and accessories, but you also want one that provides excellent customer service and support...kemblkr. 1503 posts · Joined 2013. #6 · Jun 23, 2013. Use sythetic 75/90 gear oil and change it every 100 hours or per what your manual says. Good idea to do it every other engine oil change but if it looks new you can maybe go every 3. If you ride hard in the mud and water the more often the better....your front gearbox is more important …

10 posts · Joined 2009. #6 · Dec 2, 2009. I used to do nothing but skidoo sleds for many years and I was aware that castrol made all of the oilos for bomber. And yes the price is stupid expensive for them just relabeling those products. I went ahead and paid the $32.00 for the polaris PS-4 motor oil since the mchine is new and under warrenty.To change the transmission fluid on your model year 2020 and older Sportsman 570, Sportsman 570 Utility or Sportsman Touring 570, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Ensure the vehicle is in PARK and set the parking brake. 3. Place a drain pan underneath the transmission. Placing a rag in the bottom of the drain ...Richmond, VA. Apr 20, 2017. #9. From my Cl"y"mer Repair Manual: Transmission oil Polaris synthetic gear case oil (part No. 2871478) or SAE 30 motor oil Shift selector box Polaris Premium 4 Synthetic 10W/40 or SAE 10W/40 motor oil Front hubs (4 × 4) Premium demand drive hub fluid or Type F ATF Brake fluid DOT 3 brake fluid …10 posts · Joined 2009. #6 · Dec 2, 2009. I used to do nothing but skidoo sleds for many years and I was aware that castrol made all of the oilos for bomber. And …Start engine for ONLY 10 seconds, shut down, remove oil tank drain bolt again allowing to drain and replace oil filter then drain bolt. Got this idea from OPT (an old polaris tech on ATVConnection) that got it from a Polo engineer. Works great, EZ and you won't need to perform the Crazy "priming" procedure.Feb 26, 2012 · Polaris Synthetic Gearcase Lubricant (AGL) part #2873602 = Amsoil Series 2000 Synthetic Chaincase Lube (TCC) TRANSMISSION AND TRANSFER CASE Polaris Premium ATV Angle Drive Fluid part #2871653 = Amsoil Severe Gear 75W-90 Synthetic Gear Oil (SVG) REAR GEAR CASE Polaris Premium Demand Drive Hub Fluid part #2871654 (old part #-new #2876251, my edit ...

Drain Pan. For more information on tools, read the Tools and Fasteners Guide. Always wear safety glasses and nitrile gloves when servicing your Polaris ATV. To change the transmission fluid on your Sportsman 850 or XP 1000, follow these steps: 1. Park the vehicle on a flat, level surface. 2.Mar 15, 2019 · In fact, Polaris recommended ATF for years as a substitute in the older machines right in the service manuals. 2)AGL = Automatic Gearcase Lubricant. That's your transmission oil/purple stuff. Its a chaincase oil (your Polaris tranny is a chaincase) like the oil in the transfer case of you 4x4 pickup. Polaris ATVs are known for their durability and versatility, making them a popular choice for off-road enthusiasts. However, if you’re looking to sell your Polaris ATV or buy a used one, it’s important to know its true worth. One way to det...Location. Midwest. Dec 3, 2015. #17. Just switched mine from the Polaris PS-4 oil to the AMSOIL ATV/UTV 5W-50 Oil. I like that it is the recommended viscosity and no warranty concerns since I am outside of that. Plus, Polaris doesn't make the oil that's for sure. ^^Have seen a lot of people using T-6.If you are looking for Polaris Transmission Petroleum substitutes, this article will help you analysis the best available options in and market. Skip to content. Search … Review; Blog. Review; Blog. Search … Main Menu. Review; Blog. Search for: Polaris Transmission Oil Substitute. Review / By Rayne McCain / September 12, 2022.Get a drain pan underneath, and remove the rear diff drain and fill plug bolts. Wait for the differential to completely drain. Step 2. Clean and replace the drain plug after the differential is finished draining. Step 3. Follow the same process you used to fill the transmission, but use Polaris Angle Drive fluid instead.

Nkjv john 7.

I'd appreciate some assistance identifying a good reasonably priced alternative to Polaris AGL Gearcase Lubricant and Transmission Fluid for the main gearcase (combined diff/trans). I've seen references to the following, among others: Amsoil Synthetic Chaincase and Gear Oil. Pennzoil Synchromesh Manual Transmission Fluid. …Lucas SxS Transmission Fluid was designed specifically to meet the requirements of Polaris vehicles’ Transmissions/Gearcase, including ACE, Sportsman, Ranger and …A Polaris ATV vehicle identification number, which contains the serial number, is typically on the left frame rail inside the left-front wheel well next to the fender on the right hand side. The last six characters of the VIN are the vehicl...Aug 25, 2023 · Always wear safety glasses and nitrile gloves when servicing your Polaris ATV. To change the transmission fluid on your model year 2021 and newer Sportsman 570, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Ensure the vehicle is in PARK and set the parking brake. 3. The AGL oil used by Polaris is a unique oil because the transmission configuration requires the oil to have a specific "climb-rate" to oil the upper shafts and gears of the tranny. I can't say there isn't an equivalent, but proceed with caution. Sparks Performance Products Home Page. [email protected]. 661-872-4343.

Updated: The correct oil to use in a Polaris transmission is 10W-40 synthetic motor oil. If you’re wondering what kind of oil to use in your Polaris transmission, the answer is simple – any good quality automotive transmission fluid will work fine. Just make sure to check your owner’s manual for the specific type and amount of oil ...Transmission fluid replacement for the 2014 - 2020 Sportsman 570, 570 EPS, 570 Premium, 570, 570 Utility and Touring 570. View the written article for this p...This item: Polaris AGL and Demand Drive Quarts. $4199. +. Polaris Off Road AGL Automatic Gearcase Lubricant and Transmission Fluid, Qty 1. $2199. +. Polaris Off Road Oil Change Kit for GENERAL XP 4 1000, RANGER XP 1000, RZR Trail & XP 4 1000, ACE 900 XC Models and More, 2.5 Quarts of PS-4 5W-50 Full Synthetic Oil, 1 Oil Filter, 1 Washer ...When the XP's first rolled out, they need a special kind of oil, so polaris just quickly made and bottled the XP transmission oil. They have sense worked on the AGL formula and have re-engineered the fluid to include the needs of the XP, and now call this new fluid AGL Plus. So you dont need the XP tranny fluid if you have AGL Plus tranny …No filter. I use Amsoil AFF 0-40 in the engine and trans and is rated for both applications. Drain plug accessible through opening in skid plate and fill plug on right side next to foot plate. All fluids should be replaced at least annually. I just picked up a 2000 325 Magnum and looks like the only fluid ever changed was the engine oil!To change the transmission fluid on your Sportsman 500, follow these steps: 1. Park the vehicle on a flat, level surface, ensure the vehicle is in park and set the parking brake. 2. Place a drain pan underneath the transmission drain plug. Tip: Placing a rag in the bottom of the drain pan will help prevent the splashing of fluid.Replace if necessary. 10. Reinstall the drain plug. Torque to 8 ft-lbs (11 Nm). 11. Fill the transmission through the fill plug hole until fluid reaches the bottom threads and begins to spill out. The capacity is 4 to 5 ounces (150 mL). AGL Full Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml). 12.Need help locating the full plug and drain plug. Or can I fill directly from the hole the dipstick goes in? Going to the polaris dealership in the morning for fluid. Any help would be much appreciated thank you. Drain plug is #50 and you fill through the dip stick hole. Thank you for confirming that, big help.I think the Polaris AGL has graphite in it. It's a strange gray. I use Klotz snowmobile chaincase oil with graphite, and it seems to be the same stuff. Gear oil is formulated to be a bit "sticky" as manual gear cases don't have oil pump, so the sticky oil carries onto the other gears. So, just my $.02, use Polaris AGL.Here are the different alternatives for Polaris AGL: Lucas SxS Transmission Fluid. AMSOIL Synthetic. ATV/UTV Powertrain Fluid. 5W-20 Synthetic Oil. Klotz snowmobile chaincase oil with graphite. Mobil 1 Synthetic ATF Dextron 3. Prestone ATF Full Synthetic. Transmission/Gearcase Fluid.For that reason, Red Line 43704 UTV/ATV Gearcase oil is made with the best materials to provide strength and increase the performance of the gears. According to the Product Data Sheet, This gearcase oil is a suitable replacement for Polaris AGL. So you can feel confident using it.

To change the transmission fluid on your model year 2020 and older Sportsman 570, Sportsman 570 Utility or Sportsman Touring 570, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Ensure the vehicle is in PARK and set the parking brake. 3. Place a drain pan underneath the transmission. Placing a rag in the bottom of the drain ...

Here is the info direct from AMSOIL tech services..... Michael; I hope this clarifies the recommendations. AMSOIL ATH replaces both; Front Drive Fluid/Demand Drive 2877922 and AGL 2878068-2878069 (Gearcase lubricant and transmission fluid) AMSOIL SVG replaces ATV Angle drive fluid 2876160 and 2872276 Byron Selbrede Technical Services AMSOIL INC.2019 Sportsman 850 SP Premium, Removed all Warning Decals, 3500# Polaris Winch W/Synthetic Rope, Winch Stopper Cable Line Saver, Garmin GPS176C, Ram Mount, Polaris Rear View Mirrors, 4" Front Rack Extender, ATV-GURU.COM Front and Rear Bumpers, 2" Receiver in Front Bumper, Kenda K587 HTR Bear Claws 26X9X14 & 26X11X14, Rear LED work lights ...Always wear safety glasses and nitrile gloves while servicing your Polaris RZR. To replace the transmission fluid on your RZR XP Turbo or XP 4 Turbo, follow these steps: 1. Park the vehicle on a flat, level surface. 2. Place the vehicle in PARK. 3. Place a drain pan underneath the transmission drain plug. 4. Clean the area around the fill plug.Transmission fluid replacement for the 2014 - 2020 Sportsman 570, 570 EPS, 570 Premium, 570, 570 Utility and Touring 570. View the written article for this p...Mobil 1 75W-90. Mobil 1 Synthetic Gear Lube LS 75W-90. Automatic transmission's use ATF which is a hydraulic fluid for shifting reasons. Most car manufactures also recommend ATF in Manual transmission's for fuel economy reasons. We don't baby our off-road equipment like a car & there for need to use a 75-90 or 80-90.Check Out Polaris ATV AGL Fluid on Amazon - https://amzn.to/2NEhCSaThis video walks you through how to change, the drain and re-fill the transmission fluid o...Polaris Synthetic Gearcase Lubricant (AGL) part #2873602 = Amsoil Series 2000 Synthetic Chaincase Lube (TCC) TRANSMISSION AND TRANSFER CASE Polaris Premium ATV Angle Drive Fluid part #2871653 = Amsoil Severe Gear 75W-90 Synthetic Gear Oil (SVG) REAR GEAR CASE Polaris Premium Demand Drive Hub Fluid part …It is designed to provide excellent protection and performance for Polaris ATV and UTV transmissions, differentials, and lubricated components. AGL is specifically engineered to meet the demanding requirements of Polaris vehicles. What kind of fluid goes in a Polaris transmission? In Polaris transmissions, it is recommended to use Polaris AGL ...Miker. 117 posts · Joined 2010. #7 · Aug 17, 2012 (Edited) I am looking at the Polaris Lube Chart for a 1995 Magnum 4x4. Transmission calls for 20-oz of ATV Gearcase lube. The correct AMSOIL product to use would be Synthetic Chaincase & Gear Oil. 1. 2022 RZR XP 1000 Premium Ride Command. Save.Save. turbofiat124 Discussion starter. 168 posts · Joined 2017. #9 · Apr 20, 2017. Well I stopped by Autozone yesterday and discovered a quart of Havoline 75W90 Synthetic is $14 a bottle. So there is really no cost savings advantage. The Polaris oil is $19 a quart. So now I am wondering if I can use GL-1 90 weight oil.

Magic honey para que sirve.

Leisurely study crossword.

The Ultimate Motorcycle Oil Cross Reference Guide. The cross-reference guide below offers an AMSOIL synthetic alternative for motorcycle and ATV engine and gearbox oils from over 50 oil brands, including the offerings from motorcycle makers. Oildepot offers a complete line of synthetic motorcycle oils that are a safe, reliable substitute for ...How to Change Polaris ATV Front Differential Fluids. Find the drain bolt on the bottom and the fill bolt on top of the gearcase to drain and replace the fluids in the Polaris ATV’s front differential. Place a drain pan underneath the gearcase and remove both plugs with an 8mm Allen wrench, then allow the old transmission fluid to drain out.Always change the angle drive fluid at the intervals outlined in the Periodic Maintenance Chart section. Always use SLINGSHOT Angle Drive Fluid or another Fully Synthetic 80W-90 fluid for the angle drive. See the Recommended Service Products chapter for the part numbers of recommended service products.Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmission components, to last longer, control ... 1 Gallon = 4 Quarts = 3.78L. Genuine Polaris AGL Synthetic transmission fluid is the recommended engine oil in almost all Polaris transmissions and transaxles. It is formulated to have properties which are best suited to Polaris transmissions. AGL is specially suited to Polaris ATV transaxles where a "silent chain" final-drive is used, and other.Here's what the FSM says: Engine oil - Polaris Premium 4 Synthetic 10W/40 or 10W/40 motor oil Transmission oil - Polaris synthetic gear case oil (part No. 2871478) or 30 weight synthetic engine oil Front gear case - Polaris front gear case lube (part No. 2871653), or API GL5 gear lube Front hubs - Polaris demand drive hub fluid (part No. 2871654) or ATF Type F Brake fluid - DOT 3 brake fluid ...M. magnum5 Discussion starter. 85 posts · Joined 2018. #1 · Sep 6, 2020. Hey guys, I've finally got this thing rolling and I would like to change oil in the transmission. My research shows I need Polaris Premium Synthetic Gearcase Lubricant P/N 2871478. On another forum a user quoted the manual for his Sportsman as saying it needs the same P ...Polaris Transmission Oil Substitute Royal Purple Synchromax. I know that you might be confused why I added a manual transmission fluid to this list. Though... Red Line UTV/ATV Gearcase Oil. Red Line UTV/ATV Gearcase Oil. Red Line is a reputable manufacturing firm known for producing high-quality ...If him are looking for Polaris Transmission Oil substitutes, this article will help you analyze the best available options in the market.Jul 2, 2020 · I'd appreciate some assistance identifying a good reasonably priced alternative to Polaris AGL Gearcase Lubricant and Transmission Fluid for the main gearcase (combined diff/trans). I've seen references to the following, among others: Amsoil Synthetic Chaincase and Gear Oil. Pennzoil Synchromesh Manual Transmission Fluid. 5w20 Synthetic Motor Oil. ….

This item: Polaris AGL and Demand Drive Quarts. $4199. +. Polaris Off Road AGL Automatic Gearcase Lubricant and Transmission Fluid, Qty 1. $2199. +. Polaris Off Road Oil Change Kit for GENERAL XP 4 1000, RANGER XP 1000, RZR Trail & XP 4 1000, ACE 900 XC Models and More, 2.5 Quarts of PS-4 5W-50 Full Synthetic Oil, 1 Oil Filter, 1 Washer ...oil ps-4 *diesel oil: summer 15w-40; all season 5w-40 transmission fluid agl mid/rear gearcase angle drive fluid front gearcase demand drive fluid antifreeze 50/50 extended life anti-freeze chain lube chain lube spra y oil fil ter oil change kit (extreme duty kits listed on 1.2) atv youth 50 carb youth 110 efi capacity ps-4 extreme duty oil ... Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmission components, to last longer, control ...Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmission components, to last longer, control ... In response to your inquiry, to replace the Polaris Demand Drive LT Hub Fluid we recommend our Synthetic Universal Automatic Transmission Fluid (product code ATF). It is a direct replacement for Polaris part # 2876251 & #2871654. As always, please feel free to contact us again if we can be of further assistance.1996 Polaris Xplorer 400L ATV - Transmision Fluid. I need to replace transmission oil in my Polaris ATV as maintenance for the first time. Yes it is a 1996 and oil was never changed. In service manual, Polaris recommends using their gear case lubricant but different forums talk about AMSOIL Synthetic Gear Case Lube (SGL-AGL), (TCC) Series …High-torque, heavily loaded gears are provided the proper protection and clutch chatter is prevented. Installation is fast and clean with AMSOIL Synthetic ATV/UTV Powertrain Fluid ’s easy-pack. Hopefully this blog post on the best Polaris* ATV transmission oil substitute, AMSOIL Synthetic ATV/UTV Powertrain Fluid, has been helpful. Please ...Shop 5W-50 Synthetic ATV/UTV Motor Oil at AMSOIL. Find premium synthetic oil, filters and more online. ... Formulated specifically by AMSOIL for use in Polaris* Ranger,* RZR* and Sportsman* ATVs and UTVs, providing a cost-effective, ... Put 10W-40 in the engine and transmission and it shift smoother and much easier. Polaris atv transmission oil substitute, AGL Automatic Gearcase Lubricant and Transmission Fluid, 2878069, 1 Gallon | Polaris. Skip to content Skip to navigation Skip to footer. AGL Advantage: Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ran., If you’re in the market for a Polaris ATV, it’s important to know the book value of the model you’re interested in. Knowing the book value can help you negotiate a fair price and avoid overpaying. But where do you find accurate Polaris ATV ..., Polaris PS4 Oil Analysis . Polaris PS-4 Full Synthetic 5W-50 All-Season. PS4 oil is explicitly made for Polaris powersports engines. It was developed with a custom antiwear additive system. However, it is fit to use in all 4-stroke Polaris Off-Road Vehicles, Including RZR, ATV, and Ranger. It is also fit for engines 330, 400, 500, 550, 850, and ..., Here are the different alternatives for Polaris AGL: Lucas SxS Transmission Fluid. AMSOIL Synthetic. ATV/UTV Powertrain Fluid. 5W-20 Synthetic Oil. Klotz snowmobile chaincase oil with graphite. …, 10 posts · Joined 2009. #6 · Dec 2, 2009. I used to do nothing but skidoo sleds for many years and I was aware that castrol made all of the oilos for bomber. And yes the price is stupid expensive for them just relabeling those products. I went ahead and paid the $32.00 for the polaris PS-4 motor oil since the mchine is new and under warrenty., Frequently bought together. This item: Polaris Off Road AGL Automatic Gearcase Lubricant and Transmission Fluid. $6999 ($0.55/Fl Oz) +. Polaris Off Road Demand Drive Front Gearcase and Centralized Clutch Drive Fluid, for ORVs, 2877922, 1 Quart. $2295 ($0.72/Fl Oz), Title: 13_SXS_TransmissionFluid Created Date: 6/19/2020 3:57:16 PM, Product Code: PK2-EA. 4.9 (7 Reviews) AMSOIL ATV/UTV Kits (PK1, PK2, PK3, PK4) combine everything needed to perform an AMSOIL oil change on the most popular Polaris* ATV/UTV models in one convenient package. $47.00. Retail Price (USD) Preferred Price: $35.10. Save: $11.90 Learn More. Part Number. UNIT OF MEASURE. , Jul 13, 2013 · Motor oil-Mobil 1 0W40 Synthetic. Transmission-Any 5W20 motor oil will work. Rear diff-Any good gear oil will work. I use 75W90. Front diff- I use Mobil 1 synthetic ATF. Alot of people say only use POPO fluid for the front diff which is BS. I have 10000 miles on my X2 and 8000 miles on my XP with these exact fluids. , Angle Drive Fluid Advantage: Polaris Angle Drive Fluid is a high-quality lubricant designed for Polaris ORV rear final drives to maintain peak performance longer than standard automotive or aftermarket differential fluids. Polaris Sportsman 570 Complete Service - Oil Change - Demand Drive - AGL - Air Filter - Grease., Buy Red Line 43704 UTV/ATV Gearcase Oil, 1 Quart: Motor Oils ... Polaris Off Road AGL Automatic Gearcase Lubricant and Transmission Fluid, Qty 1. ... Premium, Designed to be used with Synthetic or Conventional Oils: Fits Select Polaris Side-by-Side and ATV Models, KN-198., Its durable synthetic design makes it ideal for applications calling for either 5W-50 or 10W-50 oils. AMSOIL 5W-50 Synthetic ATV/UTV Motor Oil is formulated specifically for use in Polaris® Ranger®, RZR® and Sportsman® UTVs and ATVs. It offers a cost-effective, high-performance alternative to OEM-branded fluids., Buy Red Line 43704 UTV/ATV Gearcase Oil, ... Polaris Off Road AGL Automatic Gearcase Lubricant and Transmission Fluid, Qty 1 ... Fits Select Polaris Side-by-Side and ..., If you’re an all-terrain vehicle (ATV) enthusiast or someone looking to purchase a new Polaris ATV, finding a reliable and reputable dealer near you is crucial. Polaris is a well-known brand that offers a wide range of high-quality ATVs des..., Apr 22, 2013 · I'm going to change the transmission fluid in my 2002 Polaris Sportsman 400 some time this week. Does anyone know if there are any substances for the Polaris AGL synthetic. Can I use Valvoline CVT full synthetic transmission fluid instead? I know about the AMSOIL 2000, but I don't know who sells AMSOIL as far as places like Advanced Auto. , Skip to content Skip to navigation Skip to footer. AGL Advantage Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ra., AGL Automatic Gearcase Lubricant and Transmission Fluid, 2878069, 1 Gallon | Polaris. Skip to content Skip to navigation Skip to footer. AGL Advantage: Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ran., 10 posts · Joined 2009. #6 · Dec 2, 2009. I used to do nothing but skidoo sleds for many years and I was aware that castrol made all of the oilos for bomber. And …, This is a video I made changing out the transmission and rear differential on a buddies 2012 polaris sportsman 500 H.O.. There will be about 4 videos on this..., Shop 5W-50 Synthetic ATV/UTV Motor Oil at AMSOIL. Find premium synthetic oil, filters and more online. ... Formulated specifically by AMSOIL for use in Polaris* Ranger,* RZR* and Sportsman* ATVs and UTVs, providing a cost-effective, ... Put 10W-40 in the engine and transmission and it shift smoother and much easier., 2. Engine Oil. Oil lubricates the engine and helps prevent corrosion and rust. Checking the engine oil levels should be part of your pre-ride inspection. If you do notice that your oil levels are low, perform an oil change and replace the oil filter too. Oil changes should be performed at least once a year, or more if you ride in severe conditions., The fluid capacity is 34 ounces (1,000 ml). AGL Synthetic Gearcase Lubricant and Transmission Fluid is part number 2878068 for 1 quart (946 ml) and part number 2878069 for 1 gallon (3.78 L). 11. Reinstall both fill plugs. Torque to 12 ft-lbs (16.3 Nm). 12. Clean any residual fluid off the vehicle and inspect for leaks. 13., You are correct regarding the older Polaris numbers you referenced. Polaris numbers 2878068 and 2878069 superseded them. The AMSOIL TCC is still the recommended oil to use. We are in the process of updating and re-organizing the power sports lookup guide, and will also be updating this lubricant list in the near future., AMSOIL Synthetic ATV/Side By Side/UTV Transmission and Differential Fluid. A full-synthetic gear oil for transmissions and differentials in ATVs from brands such as Can-Am, ... A substitute for Polaris Angle Drive Fluid and “AGL” Gear Lube. April 2, 2015 / by Marc Roden Tags: atv, four-stroke, side by side. Share this entry. Share on ..., The Demand Drive fluid recommended for POLARIS ATVs and SxS/UTVs is a lubricant for the front gearcase. These machines typically deal with extreme torque and heavy loads, requiring specialized front drive oil. The schedule for changing this lubricant is generally the same as for the transmission oil: 100 hours, 12 months, or 1,000 miles., 2,535. Location. Nowthen, MN. Sep 2, 2013. #2. Angle drive is just gear lube. 75W-90 will work just fine. AGL is like a chaincase oil, much thinner than gear lube. Amsoil recommends their snowmobile chaincase lube. Demad Drive is a pretty specialized oil for the hilliard clutch that engages the front axle, and it's very thin., Mar 15, 2019 · In fact, Polaris recommended ATF for years as a substitute in the older machines right in the service manuals. 2)AGL = Automatic Gearcase Lubricant. That's your transmission oil/purple stuff. Its a chaincase oil (your Polaris tranny is a chaincase) like the oil in the transfer case of you 4x4 pickup. , Skip to content Skip to navigation Skip to footer. AGL Advantage Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Ra., 841 posts · Joined 2012. #15 · May 10, 2015. It doesnt need to state it but most all are but u definitely dont want one that says 2 stroke. Full synthetic in the right range is most important. 2015 Sportsman 1000 XP. 02 Sp700/'10 850 XP EPS sold. 2014 RZR 900 XP. 2000 Scrambler 400 2x4. -Trail Mod -RcR Ported., 10 posts · Joined 2009. #6 · Dec 2, 2009. I used to do nothing but skidoo sleds for many years and I was aware that castrol made all of the oilos for bomber. And yes the price is stupid expensive for them just relabeling those products. I went ahead and paid the $32.00 for the polaris PS-4 motor oil since the mchine is new and under warrenty., Transmission fluid replacement for the 2014 - 2020 Sportsman 570, 570 EPS, 570 Premium, 570, 570 Utility and Touring 570. View the written article for this p..., Lucas SxS Transmission Fluid was designed specifically to meet the requirements of Polaris vehicles’ Transmissions/Gearcase, including ACE, Sportsman, Ranger and RZR* and may be used safely as a substitute for AGL. Lucas SxS Transmission Fluid will not permanently shear thin, ensuring that viscosity remains constant over the life of the fluid ..., Polaris AGL Synthetic Gearcase and Transmission Fluid is a high-quality lubricant specifically designed for Polaris ATVs, Rangers, RZRs to maintain peak performance better than aftermarket fluids. The proprietary additive system of AGL is formulated using the latest technology to protect vital transmission components, to last longer, control ...